系統上位的人機界面是用VB編程，提供人機交互操作界面及數據選擇和相應的數據處理等功能。系統上位的操作界面如圖4所示。在操作界面的左上部是通訊鏈接控制框，這里只需要正確選擇PC的串口并輸入遠程PLC所連接的號碼后即可撥號鏈接，遠程的無線GSM MODEM模塊摘機響應一般設置為鈴響后自動摘機，通訊鏈接建立后，當上位PC檢測到串口端的數據載波DCD信號后，通訊鏈接控制框中的“鏈接狀態”指示燈由紅變綠，表示通訊鏈路已建立。撥號或掛機的操作均是通過對GSM MODEM模塊發送AT指令執行的。490NAE91100網絡通訊及附件

廈門仲鑫達自動化設備有限公司

：李素云

企業QQ：，2851195466

手機：

：

　　對PLC數據的讀寫操作如操作界面的右上部所示，在相應文本框內填寫好數據的類型、地址、數值和操作方式后點擊“發送”即可執行對PLC的讀或?qū)懖僮鳌＝缑娴南掳氩糠诛@示的是PC串口發送和接收的代碼以及當前操作的結果。

　　3.2 系統上位計算機的串口設置

　　在上位PC的人機界面中，串口的設置是通過下拉選擇框選擇出所連接的串口后由程序自動讀取。在使用GSM MODEM無線模塊時，上位PC對遠程PLC鏈接呼叫時采用的是AT指令。程序語句為：MSComm1.Output=“ATDT”&Trim (Text1.Text)& vbCrLf//Text1文本框內為欲連接的號碼。掛機的AT指令為：MSComml.Output=“ATDT”&“+++”& vbCrLf。串口數據格式的設定語句為：MSComml.SetTIngs=“9600. N，8.1”，與TC35iGSM MODEM無線通訊模塊和遠程PLC自由口的串行數據通訊格式一致。

　　3.3 通訊數據格式的約定

　　由于遠程PLC采用的是自由口用戶通訊方式，這里對每次收發數據字節暫約定為18個字節，數據字節的可根據實際需要而酌情約定。本系統中18個字節的約定：Bytel為數據的字節數;Bvte2為數據開始特征字;Bvte3為數據讀或?qū)懱卣髯郑築yte4為數據類型特征字;Bvte5～Byte8為PLC數據地址;Bvte9～Bytel6為PLC數據的數值;Bytel7為收發數據的校驗碼;Bvtel8為數據結束特征字。串口數據的傳輸除數據地址字節和數據數值字節用ASCII碼表示外，其他均以十六進制方式表示。因而在上位PC的編程中需涉及大量的進制轉換操作。特別要注意的是由于PLC中的實數采用32位單精度數表示，并按照ANSI/IEEE745 1985標準格式以雙字長度來存取，所以無論是上位的PC或是下位的PLC在編程時對實數數據的處理均需嚴格遵循ANSI/IEEE7451985標準格式的規定，否則將不可能讀到正確的數據。

　　New Robohand CABL-010 Sensor Cable, Picofast Female Connections, 3-Wire, 2m Long

　　New Allen Bradley 889P-F3BB-2 Quick-Disconnect Cable, Pico Straight Connection

　　Industrial Devices NH315B-18-MF1-FS2-Q-B3S Electric Cylinder Actuator w/ Brake

　　Tolomatic #8100-9080 Quick-Disconnect Cable, Female Straight Connection

　　Linemaster 632-S Clipper Foot Switch, Momentary, SPDT, 125-250VAC 20A 1HP

　　Struers Multidoser Compound Dispensing Unit 6 Bottle Capacity 24VAC 50/60Hz

　　44 Assorted Terminal Blocks on 15 1/4" Elevated Rail Single Tier *Sold AS-IS*

　　New Allen Bradley 1489-M2C005 Circuit Breaker, 2-Pole, Rated: 0.5A 400VAC

　　Robohand DPG-10-4 Parallel Gripper, Stroke: 1", Bore: 0.688", Ports: M5

　　New Banner SI-QS90F Safety Door Switch, Power: 400VAC 6A *No Key Included*

　　Parker BH4-60 Coupler With BH4-61 Nipple, Shut Off Poppet Valve, 1/2-14 NPT

　　Tescom 44-3262H283 Pressure Reducing Regulator, Inlet: 500psi, Outlet: 0-100psi

　　162 Assorted Terminal Blocks on 39" Elevated Rail 1 & 2 Tier *Sold as Pictured*

　　62 Assorted Terminal Blocks on 15 1/4" Raised DIN Rail *Sold as Pictured*

　　124 Assorted DIN Rail Terminal Blocks Two-Tier 36" Rail Length *Sold as Pictured

　　TDK Lambda DSP30-15 Power Supply 100-240VAC 0.8A In 15VDC 30W Out DIN Mount

　　New Cognex DM100S DataMan ID Reader Kit w/ Bracket, USB Cable, CD-ROM, Guide

　　Allen Bradley 1489-A Circuit Breaker 2 Pole 7A 480/277VAC 48VDC DIN Mountable

　　New Allen Bradley 1769-ECL Ser A Left End Cap for Compact I/O Modules

　　New Allen Bradley 1769-ECL Ser A Left End Cap for Compact I/O Modules

　　Tescom 44-2213-242V Regulator, Inlet: 400psig, Outlet: 0-250psig, 1/4" NPT Ports

　　Bimba M-040.5-DPBT2 Air Cylinder, Bore: 3/4", Stroke: 0.5", Ports: 1/8" NPT

　　New Marion Chicago 100S Strip-N-Stick Silicone Gasket Tape 3/8" x 1/8" x 10yds

　　MAC 411A-BOB-DP-DFBC-1BA Solenoid Valve, 5-Port 2-Position, 24VDC Solenoid

　　New Marian Chicago 300AR Strip-N-Stick Silicone Gasket 1/2" x 3/16" x 5yds

　　SMC NVFR2110R-5DZ Solenoid Valve, 5-Port 2-Position, 24VDC, *No Gasket/Screws*

　　Lot of 2 New Marian 300AR Strip-N-Stick Silicone Gasket 1/2" x 1/8" x 30'

　　SMC AFM30-N03-Z Mist Separator, Max Pressure: 150psi, Ports: 3/8" NPT

　　SMC AW20-N02H-CZ Filter/Regulator, Set Pressure: 7~125psi, Ports: 1/4" NPT

　　SMC AW20-N02C-CZ Filter/Regulator, Set Pressure: 7~125psi, Ports: 1/4" NPT

　　SMC NAW2000-N02-C Filter/Regulator, Set Pressure: 0.05~0.85MPa (7.25~123.28psi)

　　SMC AW20-N02-CZ Filter/Regulator, Set Pressure: 7~125psi, Ports: 1/4" NPT

　　SMC AF30-N03-Z Air Filter, Pressure: 150psi Max, Ports: 3/8" NPT

　　AWEH S. .401-000 Transformer 230V Pri 52/39V Sec 2kVA 3PH

　　Watlow AFCJ0FA03UK100 Thermocouple, Type K, 10FT Leads, 0.032" Diameter

　　Watlow E1E43 Firerod Cartridge Heater, Voltage: 120VAC, Power: 150W

　　Allen Bradley 700-HX86SU24 Timer Relay, Multifunction, 8-Pin, 24VAC/12-24VDC

　　Omron H5CX-A11D-N Digital Timer, Supply: 12-24VDC/24VAC, Time: 0.001s to 9999h

　　Omron H5CX-L8-N Digital Timer, Supply: 100-240VAC, Time Range: 0.001s to 9999h

　　Robohand OISN-002 Inductive Proximity Sensor, Voltage: 10-30VDC, NPN 200mA

　　New Bimba MSKX Pneumatic Reed Switch, 4.5-30VDC 200mA, NO Contact NPN

　　New Turck Bi2U-EG08-AN6X Proximity Sensor, Sensing Distance: 2mm, 10-30VDC 150mA

　　Allen Bradley 855T-BPM10 Stack Light With Red and Amber Lights, 24VAC/DC

　　Turck FCS-GL1/2A4-NAEX0/A Flow Monitoring Immersion Sensor, 4-Wire Connection

　　PowerVolt PP-4-24 Compact Power Transformer, Single Primary, Voltage: 115V

　　Fabco Air F55 CX3-10-MR Multi-Power Pneumatic Press w/ Dial-A-Stroke 8460lbf

　　Janesville Tool & Mfg A-2066 Pneumatic Press 3" Stroke 3" Bore 528lbf @ 80PSI57120001-CV

　　48990001-NK

　　48980001-AP/1 DSSB146*BAT2C

　　3HAC037084-001

　　3HAC028357-001

　　3HAC029157-001

　　3HAC026254-001

　　3HAC026253-001

　　3HAC025917-001

　　3HACO24488-001

　　3HAC13389-2

　　3HAC14178-1

　　3HAC12934-1

　　3HAC12928-1

　　3HAC14363-01

　　3HAC18159-1/03

　　3HAC035301-001

　　3HAC3180-1

　　3HAC1462-1

　　3HNE00065-1

　　3HAB8101-8

　　3HAB8101-3

　　3HAB8101-2

　　3HAB6182-1

　　3HAB9669-1

　　YB560103-CH

　　YB560103-CE

　　YB560103-CD

　　YB560103-BK

　　Janesville Tool & Mfg A-2070 Pneumatic Press 3" Stroke 3" Bore 560lbf @ 80PSI

　　Janesville Tool & Mfg A-0066 Pneumatic Press 3" Stroke 3" Bore 528lbf @ 80PSI

　　De Sta Co RP-10 Parallel Gripper, Bore: 1" Diameter, Stroke: 0.25", 10-32 Ports

　　Compact SG112-1 Angular Gripper, Bore: 1.125" Diameter, 1" Jaw Length, 1/8" NPT

　　Janesville Tool and Mfg A-3243 Pneumatic Press 1944lbf w/ Downstroke Sensor

　　Janesville Tool and Mfg A-3243 Pneumatic Press 3" Stroke 4" Bore 1944lbf @ 80PSI

　　Tescom BB-13PH1KEA4 Non-Venting Regulator, Max Inlet: 6000psi (414bar)

　　SMC VK3120-5DZ-M5-F 5-Port Solenoid Valve, 2-Position, Voltage: 24VDC, M5 x 0.8

　　Turck MS96-11Ex0-R Controller Signal Processor, Operating Voltage: 21-28VDC